3-IssuesWithOil-PlanePilotMag.pdf

Issues With Oil
Oil may be more important than fuel
By Bill Cox

Published October 22, 2013
Updated February 6, 2016

I

bought my first airplane, a Globe Swift, from a retired petroleum engineer and A&P mechanic who had lavished
hundreds of hours on his airplane. In fact, he refused to sell it to me unless I agreed to maintain it his way.

Ed Kaston lectured me several times that the typical horizontally opposed piston aircraft engine is a complex
mechanism with parts thrashing in all different directions, trying its best to tear itself apart. He explained that the
only thing preventing that destruction was oil, and that the best preventive maintenance measure I could possibly
take was simply to change the oil every 25 hours or three months, whichever came first.

He also suggested I not allow the airplane to sit for long periods of time without running it for at least 30 minutes
around the pattern. That would bring the oil up to an adequate operating temperature to burn off the contaminants
generated by lack of use.

11

I stuck to petroleum expert Kaston’s advice religiously, even hired him to do the annuals, and true to his promise,
the little 125 hp Continental ran perfectly for the eight years and 800 hours I owned the airplane.

Oil is no longer as cheap as it was in those days, but it’s probably still the least expensive and most effective
preventive maintenance measure I can take. Accordingly, I’ve become something of a student of aviation oil, and
as a result, I change it every 20 to 25 hours, guaranteed.

In the perfect engine, oil would keep every part from ever contacting any other part. Without metal-to-metal
contact, there would be essentially no wear, and a piston engine might last 5,000 to 7,000 hours or longer
between overhauls rather than the typical 1,000 to 1,500 hours we see today.

In the real world, there’s always some metal contact, because oil has a limited film strength. If two metal surfaces
are thrown together with high enough temperature and pressure, even the best oil will break down, and the
metals will begin to meet and wear.

The more frequently an airplane runs, the longer it’s liable to continue running. The late Lyle Shelton, primary
builder, owner and pilot of the unlimited F8F Bearcat Rare Bear, rebuilt his warbird in the hangar next to mine in
Compton, Calif., and Lyle kept a Cherokee 140 that his crew and I used for shagging parts or any other business
on the Bear.

Lyle’s Cherokee sometimes flew an hour or two a day, and he used to change the oil an average of about once
every two weeks. The O-320 Lycoming ran perfectly for nearly 3,000 hours, or 1,000 hours past its TBO, flying
20- to 30-minute hops around the Los Angeles basin. Even so, when the crew finally overhauled the little engine,
the cylinder walls, bearings and all the other greasy bits looked practically new.

That’s partially because Lyle used the best grade of aviation oil he could find. As most aircraft owners are aware,
automotive oil isn’t appropriate for aircraft piston engines. Auto oil is designed for engines that are water-cooled
and built to very tight tolerances. Air-cooled engines are constructed to looser tolerances and are specifically
designed to burn oil. That means auto engines operate at much lower temperatures than do aircraft powerplants.
Oils specifically intended for auto engines will break down in the high temperatures of aircraft engines. These oils
leave metallic ash additives, which, when burned in a combustion chamber, leave deposits that could cause
detonation.

Advertisement

If you need to add a quart or two of auto oil in an emergency, that’s normally not a problem, especially in high-
capacity sumps of 11 or 12 quarts, but a regular diet of motor oil as opposed to aviation oil is setting you up for a
fall.

There are two types of aviation oil, mineral or ashless dispersant, the latter sometimes incorrectly referred to as
detergent oil. Mineral oils are preferable for breaking in new or overhauled engines specifically because they
have no additives and allow the engine to “set” or stabilize oil burn before switching to ashless dispersant oil. The
rule is you can add a quart of mineral oil to a service of ashless dispersant, but don’t try to go the other way.

Though it may sound like a cliché, oil is quite literally the lifeblood of any piston aircraft engine. Anything that
interrupts the flow of oil is almost guaranteed to cause problems. For that reason, it’s important that the paper

filter be replaced or the metal filter cleaned every time you change oil. A proper oil service may therefore demand
slightly more oil than what the book calls a full sump, because you’ll need to refill the filter. An eight-quart engine
may actually demand 8.5 or even nine quarts to bring the engine to full. Conversely, the engine may tend to blow
out the top half-quart of oil. A little too much oil isn’t necessarily a bad thing.

Too little can be a major problem. For the pilot, fluctuating oil pressure could be a sign that the engine is running
low on oil. This may mean air bubbles are being fed to critical bearings rather than lubricating oil, causing
unnecessary wear.

The more frequently an airplane runs, the longer it’s liable to continue running.

Conversely, you may have little or no warning that you’re low on oil until it’s too late. I once delivered a new
Cessna T-Stationair to Sydney, Australia, and on the initial 14-hour overwater leg from Santa Barbara to
Honolulu, the engine burned 10 quarts of oil. All temperatures and pressures remained normal, and the big
Lycoming ran great for the whole trip. The next morning, when I tried to check the level, it was off the bottom of
the dipstick. Cessna pulled the engine and replaced it in Honolulu, and I kissed the ground for my good luck. Had
the leg been 15 hours…?

Oil temperature is another critical concern, and both too hot and too cold can be preludes to trouble. Every pilot
knows to watch for high oil temps, but how many pilots have seen temperatures off the bottom of the gauge? A
few years ago during an untanked winter delivery of a Cessna 400 (now Corvallis TT) from North Carolina to
Geneva, Switzerland, I saw oil temps I couldn’t believe. I was flying the leg from Bangor, Maine, to Goose Bay,
Canada, in January, and the digital oil temp on the Garmin G1000 was showing me readings consistently
between 60 and 70 degrees F. Most aircraft flight manuals prohibit even runups until oil temperature reaches 100
degrees F. At the time, OAT was about -40 degrees F, and I couldn’t find any way to keep the oil warm. It turned
out there had been a service bulletin issued by Continental requiring part of the cowling air intake to be blocked in
extreme cold weather. That bulletin hadn’t been complied with on my airplane.

On the surface, aircraft oil seems such a simple product, but my friend Ed Kaston, taught me differently. Every
time I change oil on my Mooney, I replay Kaston’s advice about the importance of proper lubrication in an aircraft
engine. The alternative isn’t even worth considering.

Place your order
(550 words)

Approximate price: $22

Calculate the price of your order

550 words
We'll send you the first draft for approval by September 11, 2018 at 10:52 AM
Total price:
$26
The price is based on these factors:
Academic level
Number of pages
Urgency
Basic features
  • Free title page and bibliography
  • Unlimited revisions
  • Plagiarism-free guarantee
  • Money-back guarantee
  • 24/7 support
On-demand options
  • Writer’s samples
  • Part-by-part delivery
  • Overnight delivery
  • Copies of used sources
  • Expert Proofreading
Paper format
  • 275 words per page
  • 12 pt Arial/Times New Roman
  • Double line spacing
  • Any citation style (APA, MLA, Chicago/Turabian, Harvard)

Our guarantees

Delivering a high-quality product at a reasonable price is not enough anymore.
That’s why we have developed 5 beneficial guarantees that will make your experience with our service enjoyable, easy, and safe.

Money-back guarantee

You have to be 100% sure of the quality of your product to give a money-back guarantee. This describes us perfectly. Make sure that this guarantee is totally transparent.

Read more

Zero-plagiarism guarantee

Each paper is composed from scratch, according to your instructions. It is then checked by our plagiarism-detection software. There is no gap where plagiarism could squeeze in.

Read more

Free-revision policy

Thanks to our free revisions, there is no way for you to be unsatisfied. We will work on your paper until you are completely happy with the result.

Read more

Privacy policy

Your email is safe, as we store it according to international data protection rules. Your bank details are secure, as we use only reliable payment systems.

Read more

Fair-cooperation guarantee

By sending us your money, you buy the service we provide. Check out our terms and conditions if you prefer business talks to be laid out in official language.

Read more

Order your essay today and save 30% with the discount code HAPPY